Product ID:AVIATION TURBINE FUEL, JP-4
MSDS Date:09/01/1988
FSC:9130
NIIN:00-273-2380
MSDS Number: BKSMK

PHILLIPS CHEMICAL COMPANY

758 ADAMS BLDG
BARTLESVILLE, OK 74004
US

Emergency Phone: 918-661-3865/8118

Info Phone: 918-661-8327

Cage: FO153

PHILLIPS PETROLEUM CO

BARTLESVILLE, OK 74004 US

Telephone: 800-234-6603

Cage: 46935

PARAFFINIC HYDROCARBONS

Fraction By Weight: >70%

OLEFINIC HYDROCARBONS

Fraction By Weight: 5%

AROMATIC HYDROCARBONS

CAS: 70995-17-8

Fraction By Weight: <25%

BENZENE (SARA III)

CAS: 71-43-2

RTECS: CY1400000

Fraction By Weight: 6-7%

OSHA PEL 1PPM/5STEL;1910.1028

ACGIH TLV: 10 PPM; A2; 9192

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:EYE/SKIN/RESPIRATORY TRACT:IRRITATION.
MOST HAZARDOUS IS EXPOSURE TO AIRBORNE MIST OR OTHER ASPIRATION
INTO THE LUNGS. ONCE INTO THE LUNGS, THIS MATERIAL IS VERY
DIFFICULT TO REMOVE AND CAN CAUSE DEAT H. PROLONGED AND REPEATED
EXPOSURES CANCAUSE DAMAGES TO THE LIVER, KIDNEYS AND CENTRAL
NERVOUS SYSTEM.
Explanation of Carcinogenicity:THIS MATERIAL CONTAINS BENZENE, A KNOWN
CARCINOGEN.
Effects of Overexposure:EYE:MILD IRRITATION. SKIN:DRYING AND DEFATTING
WITH PROLONGED CONTACT. INHALATION:HEADACHE, NAUSEA, LOSS OF
APPETITE, WEAKNESS, LOSS OF COORDINATION, CONFUSION, DROWSINESS.
ASPIRATION OF LIQUID MAY C AUSE CHEMICAL PNEUMONITIS.
INGESTION:G/I IRRITATION, NAUSEA, POSSIBLE VOMITING.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF SKIN AND
RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid:EYE: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES.
GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING AND WASH
WITH SOAP AND WATER. INHALATION: REMOVE TO FRESH AIR. RESUSCITATE
OR GIVE OXYGEN AS NEEDED-THEN GET MEDICAL HELP. INGESTION: GIVE
MILK OR WATER BUT DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION AT
ONCE.

Flash Point:-10F,-23C
Lower Limits:1.3
Upper Limits:8
Extinguishing Media:USE CARBON DIOXIDE, FOAM, OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. EVACUATE AREA. COOL
FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT, ELIMINATE SOURCES
OF IGNITION, AND VENTILATE AREA AS REQUIRED. ABSORB SMALL SPILL
WITH INERT MATERIAL OR DIKE TO RETAIN LARGE SPILL. PLACE WASTE IN
DOT APPROVED CONTAINER FO R DISPOSAL.
Neutralizing Agent:NONE

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA AWAY FROM SOURCES OF IGNITION OR OXIDIZERS. KEEP CONTAINER
CLOSED WHEN NOT IN USE. PROTECT FROM DAMAGE.
Other Precautions:"EMPTY" CONTAINERS MAY CONTAIN RESIDUE AND/OR FUMES
WHICH ARE EXPLOSIVE. DO NOT CUT,DRILL, WELD ETC. ON CONTAINERS.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL (TLV), USE NIOSH/MSHA APPROVED RESPIRATOR AS
PER CURRENT 29 CFR 1910.134, INSTRUCTIONS/WARNINGS AND
NIOSH-RESPIRATOR SELECTION.
Ventilation:MECHANICAL (GENERAL) VENTILATION IS USUALLY ADEQUATE.
Protective Gloves:RUBBER OR HYDROCARBON RESISTANT GLOVES
Eye Protection:SAFETY GLASSES/CHEMICAL SPLASH GOGGLES
Other Protective Equipment:SAFETY SHOWER AND EYE BATH. INDUSTRIAL TYPE
WORK CLOTHING AND APRON AS REQUIRED TO AVOID PROLONGED OR REPEATED
CONTACT.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING OR DRINKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
DO NO PRESSURIZE "EMPTY" DRUMS. DO NOT USE THIS MATERIAL FOR A PORTABLE
HEATER OR APPLIANCE FUEL. KEY1: NOTE! - THIS NSN HAS BEEN
CANCELLED.

HCC:F2
Boiling Pt:B.P. Text:72.0F,22.2C
Vapor Pres:2-3
Spec Gravity:0.751-0.82
Evaporation Rate & Reference:<1 ETHER=1
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, OPEN FLAMES AND OTHER SOURCES
OF IGNITION
Hazardous Decomposition Products:CARBON DIOXIDE AND CARBON MONOXIDE

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL REGULATIONS. UNUSED OR SPILL CLEAN-UP
MATERIAL WILL LIKELY BE A HAZARDOUS WASTE (CODE D001).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.